Non-Opioid Analgesic Gets Another Poor Grade for Pain Relief

By Pat Anson, PNN Editor

An expensive analgesic drug that’s often touted as a safer alternative to opioids is not reliable or effective in relieving post-operative pain, according to a new study.

Exparel is an injectable form of liposomal bupivacaine, a non-opioid local anesthetic used to numb parts of the body during orthopedic surgery and some outpatient procedures.

Because Exparel is a proprietary formulation of bupivacaine, Pacira BioSciences has priced it 10 times higher than generic bupivacaine. A 20 milliliter vial of Exparel costs about $376, compared to $38 for a same size vial of bupivacaine.

Some anesthesiologists have questioned whether Exparel is actually worth the higher cost, saying its effectiveness in relieving post-operative pain is “clinically unimportant” and no different than other local anesthetics.  

To see if they might be right, researchers at the Medical University of Vienna recruited 25 healthy volunteers for a blinded clinical study in which participants received two nerve blocks about a month apart, one with plain bupivacaine for pain control and the other with liposomal bupivacaine (Exparel).

"Since the combination of both forms of bupivacaine is recommended, little was known about the effectiveness of the use of liposomal bupivacaine alone in pain therapy during and immediately after surgery," wrote lead author Peter Marhofer, MD, a Professor of Anesthesia and Intensive Care Medicine at MedUni Vienna.

The study findings, recently published in the journal Anesthesiology, show that Exparel alone blocked pain in less than a third of the volunteers, compared to everyone who received plain bupivacaine.

“Given complete sensory blockade in merely 32% of cases, as compared to 100% with plain bupivacaine, liposomal bupivacaine does not emerge from our study as a suitable ‘sole’ local anesthetic for intraoperative regional anesthesia,” said Marhofer.

Those who did get pain relief from Exparel say it reduced their post-operative pain for up to 3.5 days. But because its effects varied from subject to subject, researchers don’t consider it a reliable analgesic when used alone.

"Our study showed unpredictable effects of liposomal bupivacaine in terms of nerve block and associated pain relief. Based on our findings, the substance cannot currently be recommended for use in pain therapy during and after surgery," said co-author Markus Zeitlinger, MD, an Associate Professor of Clinical Pharmacology at MedUni Vienna.

Pacira did not respond to a request from PNN for comment on the study. In the past, the company has aggressively promoted Exparel and used hardball tactics to silence critics.

In 2021, Pacira filed a lawsuit against the American Society of Anesthesiologists for publishing “false and misleading conclusions” in the journal Anesthesiology that said Exparel works no better than other bupivacaine products. The lawsuit was later dropped.

In 2014, Pacira took the unusual step of filing a lawsuit against the FDA, after the agency sent a warning letter to Pacira for off-label marketing of Exparel. Pacira won that case in an out-of-court settlement when the FDA withdrew its warning letter and approved the use of Exparel for more types of post-operative pain.

Over the years, Pacira has paid nearly $34 million to doctors to help promote Exparel, according to Open Payments. That strategy backfired In 2020, when Pacira paid $3.5 million to settle allegations that it gave kickbacks to doctors in the form of fake research grants.

Pacira has also been active politically, spending over $3 million on lobbying and campaign donations since 2018, according to OpenSecrets. In 2019, the company hired former New Jersey governor Chris Christie as a consultant for $800,000 and lucrative stock options. Christie had recently chaired President Trump’s opioid commission, which issued a report recommending that hospitals use more non-opioid pain relievers.

Pacira is also bankrolling Voices for Non-Opioid Choices, an advocacy group that is lobbying the Biden administration for early implementation of the NOPAIN Act. Passed by Congress in late 2022, the law requires Medicare and Medicaid to pay for Exparel and other non-opioid treatments in outpatient surgical settings, starting in 2025. Supporters of the bill want the timetable moved up to 2024, which would generate millions of dollars in additional revenue for Pacira. 

Patients Who Received Opioids During Surgery Had Better Outcomes

By Pat Anson, PNN Editor

As pressure grows on the Biden Administration to implement the NOPAIN Act and require Medicare to pay higher costs for non-opioid pain relievers during surgery, a new study shows that restricting the use of opioids during surgical procedures may do more harm than good.

Researchers at Massachusetts General Hospital (MGH) analyzed the health records of over 61,000 patients who had surgery under general anesthesia at MGH, and found that those who received opioids were less likely to experience post-operative pain and needed fewer opioids during recovery.

The study findings, published in in JAMA Surgery, showed that surgery patients who were given the opioids fentanyl and hydromorphone had less pain, lower rates of persistent opioid use, and fewer opioid prescription refills. They were also less likely to have chronic pain 12 months after surgery.

Researchers were particularly surprised to find that patients who received higher doses of fentanyl had fewer chronic pain diagnoses and needed fewer opioid prescriptions 30, 90 and 180 days after surgery.

“We were surprised by the extent to which intraoperative administration of opioids was associated with medium- and long-term outcomes. This may relate to the fact that if inadequate amounts of opioids are administered in the operating room, patients may emerge from general anesthesia in pain, a phenomenon that has a known association with persistent postsurgical pain,” wrote lead author Patrick Purdon, PhD, Department of Anesthesia, Critical Care, and Pain Medicine at MGH.

“The main implication of this study is that in the drive toward overall reduction of opioid usage in surgical pain management in the US, the role of intraoperative nociception in determining postoperative pain may have been overlooked to the detriment of patient outcomes.”

Researchers say their findings underscore the importance of ensuring that patients don’t emerge from general anesthesia in pain, not only for their short-term wellbeing, but to prevent long-term opioid use.

“The opioid crisis is a major motivator for mitigating the risks of opioid usage,” said co–first author Laura Santa Cruz Mercado, MD, an anesthesiology resident at Beth Israel Deaconess Medical Center and former research fellow at MGH. “But appropriate opioid administration in the operating room may reduce total opioid usage after surgery.”

Lobbying for Early Implementation of NOPAIN

Although previous studies have found that the risk of opioid misuse or overdose after surgery is rare, pressure on U.S. hospitals to reduce their use of opioids has resulted in a 50% decrease in opioid prescribing after surgery.  

Supporters of the NOPAIN Act would like it to decrease further and faster. Passed by Congress late last year, the Act requires the Centers for Medicare and Medicaid Services (CMS) to expand reimbursement policies for non-opioid treatments in outpatient surgical settings, starting in 2025. Supporters of the bill have launched a campaign to have the timetable moved up to 2024.

“Healthcare leaders must help CMS understand the inevitable damage that will result if the agency does not implement the policy in 2024. Millions of Americans will be put needlessly at risk of opioid addiction for another year,” Nirav Amin, MD, an orthopedic surgeon at Pomona Valley Hospital in Pomona, CA, wrote in a recent op/ed in Healthcare Dive. “The policy will incentivize greater use of non-opioids by creating separate reimbursements for the administration of these therapies.”

Unmentioned in Amin’s column is that he’s been paid over $360,000 in recent years as a consultant for Pacira BioSciences, a company that stands to directly benefit from the NOPAIN Act. Pacira makes Exparel, an expensive injectable formulation of bupivacaine, a non-opioid analgesic used to treat post-operative pain.

Bupivacaine is a generic drug that only costs about $35 a vial, while Exparel is priced 10 times higher, at $365 a vial. According to two recent studies that Pacira claimed were “false and misleading,” Exparel works no better than the much cheaper bupivacaine products.

Pacira has made over $32 million in various payments to Amin and other doctors to help promote Exparel, according to Open Payments, a CMS database that tracks industry payments to healthcare providers. Pacira is also bankrolling Voices for Non-Opioid Choices, an advocacy group that is leading the campaign for early implementation of the NOPAIN Act.

Pacira is also very active politically, spending over $2.6 million on lobbying and campaign donations since 2018, according to OpenSecrets. In 2019, Pacira hired former New Jersey governor and current presidential candidate Chris Christie as a consultant for $800,000 and lucrative stock options. At the time, Christie had recently chaired President Trump’s opioid commission, which recommended that Medicare and Medicaid reimbursement policies be changed to encourage hospitals to use more non-opioid pain relievers.